Copyright © www.batteriestransport.org 88 2.2.1_IB LITHIUM ION CELLS (including lithium ion polymer cells) Small cells partially excepted UN 3480 Application Lithium ion cells with a Watt-hour rating not exceeding 20 Wh/cell IATA Only Lithium ion cells with a Watt-hour rating not exceeding 20 Wh/cell transported in quantities that exceed the allowance permitted in § 2.2.1_II: • lithium ion cells with a Watt-hour rating ≤ 2.7 Wh/cell exceeding 2.5 kg net quantity per package; • lithium ion cells with a Watt-hour rating 2.7 < Wh ≤ 20 per cell, exceeding 8 cells per package. UN No., Proper Shipping Name UN 3480, LITHIUM ION BATTERIES Class 9 IATA Only Packing Group Not assigned Hazard Label • Labels must be in the form of a square set at an angle of 45° (diamondshaped) with minimum dimensions of 100 mm by 100 mm; except for air transport mode, labels dimensions may be reduced in the case of packages of such dimensions that they can only bear smaller labels. • They must have a line 5 mm inside the edge and running parallel with it. Prerequisite • Cells must meet the General Requirements of § 1.3 in particular the test requirements Transport mode ADR IMDG IATA Passenger Aircraft Cargo Packing Instructions SP 188 SP 188 PI 965 section IB Forbidden State of Charge (SoC) ≤ 30 % of their rated design capacity Exemption conditions Cells must be protected so as to prevent short circuits, including protection against contact with conductive materials within the same packaging that could lead to a short circuit. Cells must be packed in inner packagings that completely enclose the cell. The inner packagings must be packed in strong outer packagings Packaging Drums, Jerricans, Boxes; not required approved packaging. Use strong outer packaging, it must be capable of withstanding a 1.2 m drop test in any orientation without damage to cells contained therein, without shifting of the contents so as to allow cell to cell contact and without release of contents . Restriction: see § 1.9.3 Each package must be capable of withstanding a stacked test to a height of 3 m for 24 hours Weight limit 30 kg Gross 30 kg Gross Forbidden 10 kg Net Marking and Labelling of Packages Minimum dimensions: 100 × 100 mm For small packages reduced to 100 mm × 70 mm UN 3480, LITHIUM ION BATTERIES Full Name ad Address of the shipper and the consignee Net weight Minimum dimensions: 100 × 100 mm For small packages reduced to 100 mm × 70 mm Minimum dimensions: 120 × 110 mm Overpack OVERPACK + same labels as above OVERPACK + same labels as above OVERPACK + same labels as above Restriction: see § 1.9.3 Documents Transport document is not required MDGF is not required Shipper’s Declaration
RkJQdWJsaXNoZXIy MjQwNg==